Loading...
The URL can be used to link to this page
Your browser does not support the video tag.
Home
My WebLink
About
8327 Gallery Ln Ne_BLD4269_2026
CITY OF ARLINGTON 18204 59th Avenue NE,Arlington,WA 98223 INSPECTIONS: 360-403-3417-Permit Center:360-403-3551 BUILDING PERMIT 8327 GALLERY LN NE Permit#:4269 Parcel#:00874400005700 PERMIT EXPIRES 180 DAYS AFTER DATE OF ISSUANCE. Scope of Work:Gas furnace install Valuation: .00 OWNER APPLICANT CONTRACTOR BROWN PATRICIA M CM Heating CM Heating Inc PO BOX 537 1415 Broadway 1415 Broadway ARLINGTON,WA 98223 Everett,WA 98201 Everett,WA 98201 4252590550 425-259-0550 LIC:CMHEAIx095R4 EXP:05/04/2023 Wiffi iW64,CONTRACTOR PLUMBING CONTRACTOR CM Heating Inc 1415 Broadway Everett,WA 98201 425-259-0550 LIC#:CMHEAI*095R4 EXP: 05/04/2023 LIC#: EXP: PERMIT TYPE: Residential Mechanical CODE YEAR: 2018 STORIES: CONST.TYPE: DWELLING UNITS: OCC GROUP: BUILDINGS: OCC LOAD: _-, _ _ The issuance or granting of this permit shall not be construed to be a permit for,or approval of,any violation of this Code or any other ordinance or order of the City,of any state or federal law,or of any order,proclamation,guidance advice or decision of the Governor of this State.To the extent the issuance or granting of this permit is interpreted to allow construction activity during any period of time when such construction is prohibited or restricted by any state or federal law,or order,proclamation,guidance advice or decision of the Governor of this State,this permit shall not authorize such work and shall not be valid.The building official is authorized to prevent occupancy or use of a structure where in violation of this Code,any other City ordinances of this jurisdiction or any other ordinance or executive order of the City,or of any state or federal law,or of any order,proclamation, guidance advice or decision of the Governor.The building official is authorized to suspend or revoke this permit if it is determined to be issued in error or on the basis of incorrect,inaccurate or incomplete information,or in violation of any City ordinance,regulation or order,state or federal law,or any order,proclamation,guidance or decision of the Governor. I AGREE TO COMPLY WITH CITY AND STATE LAWS REGULATING CONSTRUCTION AND IN DOING THE WORK AUTHORIZED THEREBY,NO PERSON WILL BE EMPLOYED IN VIOLATION OF THE LABOR CODE OF THE STATE OF WASHINGTON RELATING TO WORKMEN'S COMPENSATION INSURANCE AND RCW 18.27. THIS APPLICATION IS NOT A PERMIT UNTIL SIGNED BY THE BUILDING OFFICIAL OR HIS/HER DEPUTY AND ALL FEES ARE PAID. IT IS UNLAWFUL TO USE OR OCCUPY A BUILDING OR STRUCTURE UNTIL A FINAL INSPECTION HAS BEEN MADE AND APPROVAL OR A CERTIFICATE OF OCCUPANCY HAS BEEN GRANTED. IBC110/IRCI 10. SALES TAX NOTICE: Sales tax relating to construction and construction materials in the City of Arlington must be reported on your sales tax return form and coded City of Arlington#3101. 12/8/2021 Signal I'rmt N•mr )ate Released By Date CONDITIONS Adhere to approved plans.Call for inspections. THIS PERMIT AUTHORIZES ONLY THE WORK NOTED.THIS PERMIT COVERS WORK TO BE DONE ON PRIVATE PROPERTY ONLY. ANY CONSTRUCTION ON THE PUBLIC DOMAIN(CURBS,SIDEWALKS,DRIVEWAYS, MARQUEES,ETC.)WILL REQUIRE SEPARATE PERMISSION. PERMIT FEES Date Description Fee Amount 12/08/2021 Processing/rechnology $25.00 12/08/2021 Inspection $75.00 12/08/2021 Forced Air Heat $15.00 12/08/2021 Mechanical Base $25.00 12/08/2021 Credit Card Service $4.20 Total Due: $144.20 Total Payment: $144.20 Balance Due: $0.00 CALL FOR INSPECTIONS Call by 3:30 pm for next day inspection,allow 48 hours for Fire Inspections When calling for an inspection please leave the following information: Permit Number,Type of Inspection being requested,and whether you prefer morning or afternoon RESIDENTIAL MECHANICAL PERMIT APPLICATION l,7NG'� Department of Community& Economic Development City of Arlington • 18204 59th Ave NE• Arlington,WA 98223• Phone(360) 403-3551 THIS APPLICATION IS TO BE USED WHEN APPLYING FOR NEW MECHANICAL INSTALLATION AND OR GAS PIPING FOR EXISTING RESIDENCES. PLEASE FILL OUT ALL PAGES OF THIS APPLICATION AND INCLUDE ALL INFORMATION. Project Address:8327 GALLERY LN Project Description:GAS FURNACE INSTALL Owner: CHRISl1NE PAYETiE Address: 8327 GALLERY LN City: ARLINGTON State WA Zip Code: 98223 Phone: 4252326672 Email:cpayette3@gmaii.com Applicant: HANNAH HAGEAGE Address: 1415 BROADWAY City: EVERETT State WA Zip Code: 98201 Phone: 4252590550 Email: HHAGEAGE@CMHEATING.COM CONTRACTOR INFORMATION Contractor Name:CM HEATING Address: 1415 BROADWAY City: EVERETT State WA Zip Code: 98201 License Number:C M H EAI*095R4 Expiration: 12/2021 Phone:4252590550 Email:HHAGEAGE@C MH EATING.COM STAFF USE ONLY Received Permit #: '�Z Accepted by: '�� Date:140-V $-20 6/16LP Page 1 of 2 '�. RESIDENTIAL MECHANICAL PERMIT APPLICATION 111v(s1 Department of Community& Economic Development City of Arlington • 18204 59th Ave NE• Arlington,WA 98223• Phone(360) 403-3551 SELECT ALL PROPOSED APPLIANCES Furnace (80+) Model #GCEC800603BX AFUE80 _ ❑ Heat Pump Model # AFUE HSPE ❑ AC Unit Model # SEER ❑ Freestanding Stove ❑ Fire Place Insert ❑ Outdoor BBO ❑ Gas Piping ❑ Solid-Fuel Appliance ❑ Other Gas Piping Information Not Applicable: 14 Pipe Material: Pipe Size: Distance from Meter to Furthest Appliance: Total BTU's of all Appliances: • New gas piping requires a pressure test hooking to any appliance • Sediment traps (drips) are required on all gas lines • Gas lines are required to be supported/secured every 6 to 8 feet • Proper Combustion air and venting required for all appliances • A shut-off valve is required within 6 feet of all appliances k!�"Ic Applicant Signature: Date: 11/18/2021 Applicant Printed Name: HANNAH HAGEAGE I hereby certify that the above information is correct and that the construction, installation for the above mentioned property will be in accordance with the applicable laws of the City of Arlington and the State of Washington. 6/16LP Page 2 of 2 INSTALLATION INSTRUCTIONS FOR TABLE OF CONTENTS *MEC80* & *CEC80 Safety Considerations.....................................................2 Product Application..........................................................4 GAS FURNACE Location Requirements & Considerations.......................5 Combustion &Ventilation Air Requirements....................8 (Type FSP CATEGORY I Direct Exterior Masonry Chimneys..........................................10 or Non Direct Vent Air Furnace) Electrical Connections...................................................13 (Type FSP CATEGORIE I Direct Gas Supply and Piping..................................................14 Circulating Air................................................................17 ou four A air souffle non direct) Electrical........................................................................17 Circulating Air& Filters..................................................24 These furnaces comply with requirements Airflow Tables ................................................................28 embodied in the American National Standard Wiring Diagram..............................................................45 / National Standard of Canada ANSI Z21.47•C- Maintenance..................................................................46 SA-2.3 Gas Fired Central Furnaces. Before Leaving an Installation.......................................46 Repair and Replacement Parts .....................................47 A WARNING c OOT us ONLY PERSONNEL THAT HAVE BEEN TRAINED TO INSTALL,ADJUST,SERVICE OR Installer. REPAIR(HEREINAFTER,"SERVICE")THE EQUIPMENT SPECIFIED IN THIS MANUAL Affix all manuals SHOULD SERVICE THE EQUIPMENT.THE MANUFACTURER WILL NOT BE RESPONSIBLE ntertek adjacent to the unit. FOR ANY INJURY OR PROPERTY DAMAGE ARISING FROM IMPROPER SERVICE OR SERVICE PROCEDURES. IF YOU SERVICE THIS UNIT,YOU ASSUME RESPONSIBILITY FOR ANY INJURY OR PROPERTY DAMAGE WHICH MAY RESULT. IN ADDITION,IN As a professional installer you have an obligation to know JURISDICTIONS THAT REQUIRE ONE OR MORE LICENSES TO SERVICE THE EQUIPMENT the product better than the customer.This includes all safety SPECIFIED IN THIS MANUAL,ONLY LICENSED PERSONNEL SHOULD SERVICE THE precautions and related Items. EQUIPMENT. IMPROPER INSTALLATION,ADJUSTMENT,SERVICING OR REPAIR OF THE EQUIPMENT SPECIFIED IN THIS MANUAL,OR ATTEMPTING TO INSTALL,ADJUST, Prior to actual installation, thoroughly familiarize yourself SERVICE OR REPAIR THE EQUIPMENT SPECIFIED IN THIS MANUAL WITHOUT PROPER with this Instruction Manual. Pay special attention to all TRAINING MAY RESULT IN PRODUCT DAMAGE,PROPERTY DAMAGE,PERSONAL safety warnings. Often during installation or repair it is INJURY OR DEATH. possible to place yourself in a position which is more hazardous than when the unit is in operation. PROP 65 WARNING FOR CALIFORNIA CONSUMERS Remember, it is your responsibility to install the product IQ WARNING safely and to know it well enough to be able to instruct a customer In Its safe use. Cancer and Reproductive Harm- Safety is a matter of common sense...a matter of thinking www.P65Warnings.ca.gov before acting. Most dealers have a list of specific good safety practices...follow them. Q The precautions listed in this Installation Manual are "RECOGNIZE THIS SYMBOL intended as supplemental to existing practices. However, AS A SAFETY PRECAUTION. if there is a direct conflict between existing practices and .NOTE: Please contact your distributor or our website for the content of this manual, the precautions listed herein the applicable Specification Sheet referred to in this manual. take precedence. IOG-2022 5151 San Felipe Suite 500• Houston, TX 77056 05/2019 www.goodmanmfg.com • www.amana-hac.com ©2019 Goodman Manufacturing Company, L.P. Amana, is a registered trademark of Maytag Corporation or its related companies and is used under license. All rights reserved Z -lenuew s!uJ}o uolJoas JNldld aN'd 1.1ddnS svo ui paI}!oads se 'suolJoauuoo Ile Noaua of s�eal }o uo!Joolop ay} Jo} Alleo!}loads apew uoi}nlos deos algel!ene AllelOJaw -woo a ash 'aweli uado ue uJ!M SNeal se6 Jo} JSaJ JanaN -lenuew S1gj Jo uo!Joas u!Juan L AjobeleZ) u! pa!}!oads Se 'Aluo wa;SAS Juan paAoJdde ue of ooeuJnj s!uJ Joauuo0 'sJoopJno auJ of pa6Jeuos!p aq Jsnw sJanpo.Id uolJsngwo0 'WUtlH 3nll:)naoad3a 113HIO UO SIAM 'Ienum Sly;jO UOI138S S_LN31AJ3Wn 3U HIU19'U3JNtl:)3Sntl:)01 VINUOJIIV:)10 31V1S 3H1 01 NMONN HIV NOI VIUN3A 18 NOI1Sn8W00 u! pa!}loads se ooeu 3UV H3IHM aNV HIV30 UO SS3N111 Snom3S 3SnV3 AVW HJIHM -in} auJ of JIe UOIJeIIJUaA pUe uolJsngwo0 aJenbape ap1AOJd S1V31W3H3 HO 1V71W3H3 V S33na0Ud UO SNIVINOD 13n00Ud SIHl 'lenuew s!uJ}o uo!Joas SNOIlISOd N011b'11VISNl pue uo!; JNINMVM® -oas SNO.11Vb IGISN00'8 S1N3W3bin 32i NOUV001 u! pa!}laads se uo!J!sod pue uo!Jeool a u!Aluo aoewn}s!uJ IleJsul U3llddn5 Stl9 9HI UO AJN39V D AUM'U311V1SNI 031311tlnb tl A9 03WUOAAd 39 15nA TMAU3S 0NV NOUV11V1SNJ— lenuew SIIIJ}O u01108s SN0I1V11V1SNl 3anilllb HOW 'IN3WIUVd30 /SV9 3Nb'dOHd auJ UI paJSll J!N UOISJanuOo -d-1 aJepdoJdde 31d13 3H111tlJ'H311ddns stl9 UnOA H7tl3U IONNVJ nOA Jl . eqj bu!sn Aq se6 -d-1 uo aJeJado of paJJanuoo plc!} aq Aew 'SNOIJUnUlSNI S,U31lddns SV9 3Hl M0110j '3NOHd JI 'se6 leJnJeu ql!M asn Jo} poinJoe}nuew sI ooeuJn} s!ul S,U09H913N V WOU3 U311ddns SV9 UnoA 11VJ k13iV1G3AAl . '9NIOlIn9 UnOA NI 3NOHd ANV 3sn lON 00`HUiIMS 1VJIUJ0313 ANV HJnO110N 0(1 . •slaualew sagewwop sap no saJnssalq sap':wow e! 30Ntlllddtl ANtl IH911 Ol AU110N O(1 JauieJlua;nad !nb a:)'aJlnpoid as ap anbslJ uo!soldxa aun :SV9113WS nOA 31 Oa 011bHM— no a!puaou!un 'sal!n}ap uo!;:)alap el Jnod juawale!oads 3�NVI1ddV U3H1O ANV UO SIHI do AIINDIA 3Hl NI SOInnn an5uo:)alepJawwo]asnauUOAeS uoiInlos aun 0NV SUOdVA 319VWWV13 U3H10 UO 3N110SV9 3sn UO 3UOlS ION OQ— ]Uesllgn ua spJOJ3eJ sal snot Jal}IJaA'anu awwel}aun,p '3311 30 SSoi UO AUnfN11VNOSU3d'39VWtla uaAow ne zeS ap sal!n}ap azuasa.ld e!Ja!}IJaA s!ewef aN AIU3dO11d 9NISm 11nS3U AVW NOISO1dX3 UO 3U13 V'Al1JVX3 a3MO1103 ION SI SNoinnalSNI 3S3H1 Ni NOIIVWUOANI 3H1 it 'slalJa}ew Sagewwop JNIN21b�M� sap no saJnssalq SaneJS ap'IJow el JauieJJua}nad ela3 aJj}aj e! a S@lA!ns sed Juos au al!Jn:)as ap sauBlsuo:)sal IS a3llddn5 SV9 3HI N0IS01dX3,a nO TaNDN1,0 3nbsla UO A3N39V U331AMS'U311VISN1 a31311Vnb V 1lnSNOJ'NOIIVWUOJNI UO 3:)NVISISSV IVNOIIIUGV Hod '1VnNVW SIHI Ol a3J3a 1N3W3SSI1213AH a '3:)NVN3INIVW UO DIAMS'NOUVU311V'1N3W1SnfaV'NO1IV11V1SN1 U3dOUdWI 013na HIM UO AanfNl 1VNOSU3d IN3A3Ud Ol @}!l}o sso!JO AJnfUI leuosJad'a2lewep A}JadoJd 2u!sneo jlnsaJ Aew uo!soldxa Jo aJI}V'suo!l�auuo� EJNINMVMIW !le ION:)01 Wa!}o u01P@1@p aylJo}A!!eo!}Dads @pew uo!;nlos deos algel!ene Allei:)Jawwoo a ash 'awel}uado ue 41Im seal se;l Jo}Jsaj JanaN lenuew slut 10 uo!}oas N011b'011ddV lOnG08d auJ Ul paJs!l aJe suO!J!puoo asaul-Jaw aJe Suo!J!puoo Uie}Jao 'aSewep AliadoJd Jo 4leap`AJnfu!sno!Jas uI }!Aluo Ja}eau el!s uo!JanJJsuoo a se pasn aq stew eoewn}siul jInsaJ pino:)Alpexa sgu!weM Aja}es aqj Mollo}of aJn!!ej 'lenuew s!uJ}o uo!;oas SN0I1VU901SNOD ONV S1N3W38in 3b N011`d001 eqj ui pa!J!aads se palleJsu!aq 021F/Zt1H N0IS01dX3 210 32113 Ism ebeaeb leguaplsaJ a u!uo!JelleJsu!Jo}ooeuJnj paJ!J-se6 V ONINUV W -6u!seo eoeuJn}auJ of paleas aq pue Jonp Alddns auJ se coeds awes auJ u! aJeuiwiel Jsnw Jonp J!e uJnJaJ a 'ooeuJnj aqj 6u! -u!eJuoo coeds eqj ap!sJno Jie Alddns (s)Janp aoewn} uagM Janpold s!uJ�o uo!Jealldde pue uolJelleJsui auJ of buiu!eJJad so!}!oads Jol lenuew s!uJ 'suo!JonJJsui asegj jo uo!Jt)as SM33HO peal Alu6noJouJ 'uo!JeJado pue uoiJelleJsu! JadoJd aJnsua 1VN011VH3d0 pue aJeld 6ugeJ aaeuJn} auJ uo peq!oeds of 'aoeuJnj eqj bulJeJado Jo `buiouuas 'buuaJle '6u!Jsnfpe se 'abueJ olgemolle auJ uigl!M aJnssaJd a!JeJs leujelxe seu '6u!lle}sui uegm suoiJneo pue s6u!uJeM 6u!Mollol auJ of aJaupV ga!uM welsAs Jonp a uJ!M 96ueJ asp-aJnJeJadwaJ popuaJui s,aoeuJnj auJ u!uJ!M ejeJado of eoeuJnj a IleJsu! sAeMIV SN0/1VH3(71SN0:) A13_4VS ,I •,I DANGERA . A Pl�,I- I G R 0 A CARBON MONOXIDE POISONING HAZARD RIESGO DE INTOXICACON POR MONbXIDO DE CARBONO RISQUE D'EMPOISONNEMENT AU MONOXYDE DE CARBONE Special Warning for Installation of Furnace or Air Handling Units In Advertencia especial para la instalaci6n de calentadares 6 manejadoras Advertencia especial para la instalacion de calentadores 6 manejadoras Enclosed Areas such as Garages,Utility Rooms or Parking Areas de afire en areas cerradas coma estacionamientos 6 cuartas de serviclo- de aire en Areas cerradas Como csWFonamfenms 6 cuertos de urvilm. Carbon monoxide producing devices(such as an automobile,space Los equipos o aparatos que producen monoxido de carbon Avertissement special au sujet de('installation d'appareiis de hauffage heater,gas water heater,etc.)should not be operated in enclosed areas (tal coma autom6vil,calentador de gas,calentador de agua par media de ou de traitement d'air clans des endralts clas,tets les garages,les locaux such as unventilated garages,utility rooms or parking areas because of d'entretien et les stationnements.Evitez de mettre en marche les the danger of carbon monoxidepoisoning resulting from the exhaust gas,etc)no deben ser operados en Areas cerradas debido al riesgo g (CO)( )p g g de envenenamiemo par mon6xido de carbon(CO)que results de las appareils produlsant du monoxyde de Carbone(tels que les automobile, emissions.If a furnace or p handlers installed in an enclosed area such les appareils de chauffage autoname,etc.)clans des endroits non as a garage,utility room or parking area and a carbon monoxide producing emisiones s,gases xi rombustidn.Si el equipo d aparatoect se opera en ventllEs tels que les d'empoisonnement au monoxyde de Carbone.SI vous device is operated therein,there must be adequate,direct outside dlchas Areas,debe exlstlr una adecuada ventllacidn directs al exterior. ventilation. Esta ventilation es necesaria para evitar el peligro de envenenamienlo devez faire fonctionner ces appareils dens un endrait clos,assures-vous This ventilation is necessary to avoid the danger of CO poisoning which par CO,que puede ocurrir si un dispositivo que produce monoxido qu'il y ait une ventllatlon dlrecte provenant de I'exterter. can occur if a carbon monoxide producing device continues to operate in de carbono sigue operando en el lugar cerrado. Cette ventilation est necessaire pour eviter le danger d'intoxication the enclosed area.Carbon monoxide emissions can be(re)circulated Las emisiones de monoxido de carbono pueden circular a trav6s au CO pouvant survenlr sl un appareil produlsant du monoxyde throughout the structure if the furnace or air handler is operating in any del aparato cuando se opera en cualquier modo. de carbone continue de fonctionner au sein de la zone confines. mode. CO can cause serious illness including permanent brain r0mon,.,�,.Ido de carbono puede causar enfermedades severas Les Emissions de monoxyde de carbone peuvent etre recircules dans les damage or death. BI@59-216o cerebral permanente 6en 810259-216 endralts clas,sil'appareil de chauffage ou de traitement d'alr sont en marche. Le monoxyde de Carbone peut causer des maladies graves telles que des dommages permanents au cerveau et meme la mort. 61a259-216 A WARNING A WARNING HEATING UNIT SHOULD NOT BE UTILIZED WITHOUT REASONABLE, TO PREVENT PERSONAL INJURY OR DEATH DUE TO IMPROPER ROUTINE,INSPECTION,MAINTENANCE AND SUPERVISION. IF THE INSTALLATION,ADJUSTMENT,ALTERATION,SERVICE OR MAINTENANCE, BUILDING IN WHICH ANY SUCH DEVICE IS LOCATED WILL BE VACANT, REFER TO THIS MANUAL. FOR ADDITIONAL ASSISTANCE OR CARE SHOULD BE TAKEN THAT SUCH DEVICE IS ROUTINELY INSPECTED, INFORMATION,CONSULT A QUALIFIED INSTALLER,SERVICER AGENCY OR MAINTAINED AND MONITORED.IN THE EVENT THAT THE BUILDING THE GAS SUPPLIER. MAYBE EXPOSED TO FREEZING TEMPERATURES AND WILL BE VACANT, ALL WATER-BEARING PIPES SHOULD BE DRAINED,THE BUILDING SHOULD BE PROPERLY WINTERIZED,AND THE WATER SOURCE CLOSED.IN THE ©WARNING EVENT THAT THE BUILDING MAY BE EXPOSED TO FREEZING TEMPERATURES AND WILL BE VACANT,ANY HYDRONIC COIL UNITS TO PREVENT PERSONAL INJURY OR DEATH DUE TO ASPHYXIATION,THIS SHOULD BE DRAINED AS WELL AND,IN SUCH CASE,ALTERNATIVE HEAT FURNACE MUST BE CATEGORY I VENTED. DO NOT VENT USING SOURCES SHOULD BE UTILIZED. CATEGORY III VENTING. PROVISIONS MUST BE MADE FOR VENTING COMBUSTION PRODUCTS OUTDOORS THROUGH A PROPER VENTING SYSTEM.THE LENGTH OF A WARNING FLUE PIPE COULD BE A LIMITING FACTOR IN LOCATING THE FURNACE. TO PREVENT POSSIBLE PROPERTY DAMAGE,PERSONAL INJURY OR DEATH DUE TO ELECTRICAL SHOCK,THE FURNACE MUST BE LOCATED TO ADDITIONAL SAFETY CONSIDERATIONS PROTECT THE ELECTRICAL COMPONENTS FROM WATER. This furnace is approved for Category I Venting only. • Provisions must be made for venting combustion AWARNING products outdoors through a proper venting system. SHOULD OVERHEATING OCCUR OR THE GAS SUPPLY FAIL TO SHUT OFF, The length of flue pipe could be a limiting factor in locating the furnace. TURN OFF THE MANUAL GAS SHUTOFF VALVE EXTERNAL TO THE FURNACE BEFORE TURNING OFF THE ELECTRICAL SUPPLY. SHIPPING INSPECTION AWARNING All units are securely packed in shipping containers tested ac- cording to International Safe Transit Association specifications. POSSIBLE PROPERTY DAMAGE,PERSONAL INJURY OR DEATH DUE TO The carton must be checked upon arrival for external damage. FIRE,EXPLOSION,SMOKE,SOOT,CONDENSATION, ELECTRICAL SHOCK If damage is found, a request for inspection by carrier's agent OR CARBON MONOXIDE MAY RESULT FROM IMPROPER INSTALLATION, must be made in writing immediately. REPAIR OPERATION,OR MAINTENANCE OF THIS PRODUCT. The furnace must be carefully inspected on arrival for damage and bolts or screws which may have come loose in transit. In the event of damage the consignee should: 1. Make a notation on delivery receipt of any visible damage to shipment or container. 2. Notify carrier promptly and request an inspection. 3 ao wnw!u!w'as!a ain;eladwaliie bu!;elnojio'suo!}oauuoo leo!.1J ao; 1101109s 6'£ZZZ ISNH/b9 b'dJN o} 6u!p.I000e;onp -oalo jeclold 'bu!}ej;ndul nie 'sainssaid seb'ainssaid o!;e;s sigl az!S -aoeuan;ay;of AlJoajlp Jonp s!y;Joauuoo IOU leu.la;xe wnwlxew ;!un :o} pel!w!l ;ou ;nq 6uipnlou! 'o; pajay op—uo!Jsngwoo jo;aoeuan;ay}of me ap!slno Alddns -pe aq ;snw yo!yM swel! o!;loads y}!M;lasjnoA aziae!l!wel o} of pasn aq Aew 6ui;onp Ajejodwei -uoiJon.1}suoo Algbnoaoy;lenuew s!yJ peaa aseeld '}!un sigj bu!lle;sw aao;a8 6ui.lnp uo!Jsngwoo.lo;pasn aq}snw a!e ap!slno%006 NEITIV1SN1 3Hl Ol .aleld 6u!}ej aoeuan; ay;jad ;as aje esij ain}ejadwal pue aJe.I Jndu! aqj •;oafgo papunoa6un -uo!;ona;suoo Aue bulyonol aao;aq s.lauie;uoo a!ayJ of sloquoo Mau ;o uo!;aldwoo uodn pue uoiJon.l;suoo 6u!anp Al!ep ao plo Aue u.1n;a�l •aoeuan; a uo loa;uoo ay; bu!lle;sui peoeldaa pue wa}sAs ay; u1 palle;sul aae saa;l!; a!y ;! £ y6no.ly; l, sda}s mollod •jau!e;uoo s;! woa; lOa;uoo -pauie}u!ew s! (0.LZ) Jo08 PUB Mau a 6UTAow9J aao;aq punoa6 of Apoq.1noA 96aeyos!d .t, (0096) d009 ueamleq abuea ain;eaadwal a!e uan}aa y •saa!M Jo lwJuoo -aoeuan; 6u!yono} aao;aq Z da}s Jeadai ';oafgo papuna6un ue ay} of paleas pue p9p!Ao.1d aae s}onp j!e uan}a�j 4m loe;uoo ui ewoo noA ll •(•o}a 's}oafgo papunoa6un •uo!Jona}suoo buunp pasn aq IOU }snw uo!Jeaq!A yono; IOU op 'Jaa; anoA 914nys ao aAOw IOU op '•a•!) �(q pa}oa}}e JeJsowaay}Aue ao 's}e;sowaay; le;aw-!8 'Aj!oujoala o!Je;s y;!M Apoq anon(a6aeyoaa o;;0u uo!Jneo •abewep ;uawd!nbe waal buol asneo ueo pue pasn asn •Z da}s ui ss000ad 96aeyos!p ay} 6u!Mollo; bu!a!M aq l0NNb'3 6u!Jeay snonuiJuoo ap!noad;ey;saadwnf bu!;oauuoo ao alnpow loa;uoo pa;ea6a;u! ao!AJOS -£ pax!j•aoeuan;ay}loa;uoo of pasn s!;e;sowjegj woa y pa6aeyosip aq p!M 6u!punoa6 6u!anp puey suo!JonaJsu! uo!JelleJsu! s,uosaad a ui play sloo;Auy -la;uoo ay;aeau sooeuin; asay)aad palle}sui Al}uouewied s! wa}SAS Juan ayl ay};o aoe}ans le}aw `paJu!edun `uealo a yono} �(lwa!� •Z :Jaw aae SUOf;fpuOo SULMOJpo; ayj;O pe;f -punoa6 o; a6aeyo A71N0 aaleay ajls uol}onalsuoo a se pasn aq Am aoeuan;siyl o!;e;soa}oale s,Apoq anon( bu!6aeyos!p of ao!ad loa}uoo ay}of pa}oauuoo aa!M Aue ao alnpow loa;uoo pa;ea6a}u! -Aldde suo!Jo!a}saa pue suo!snloxe AlueaaeM aay;o py ay}yono;Jou oa •aoeuan;ay}o;aaMod lle;oauuoos!Q -6 •Jiun a!e „dn-anew„ a se pasn aq IOU }snw }I seoeuin;(papunoa6un) palle;su!-uou •uo!Jeo!ldde tiaA!lap Ae aaa; pue palle;sui y}oq of algeo!ldde si anp000ad s!yl -a6aeyo e u! asn ou ue wa s�(s a on e o lied a -sip o!;e;soa}oala of alnpow loa}uoo palea6a;ui ay} 6u!sodxo p } p } p ; p ; }� q}snw Jl pione dlay ll!M sda}s asay; 'le!;ua;od o!Je}soa;oala awes ay} .01!s uo le uosaad ay} pue 'loa}uoo ay; `aoeuan; ay} bu!J;nd A8 -abe paJona;suoo buipl!nq a ui saoopui palle}su! aq;snw Jl -wep wa; alnpow loa;uoo paleiba}ui ay;;oa;oad of bu!o!Aaas -sapoo leuoiJeu pue leool aad pue pap!Aoad pue uoi;elle;sui aoeuan;bu!anp suo!;neoaad 6u!Mopo;ay}asn suo!}ona}sui uo!;elle;sui ay} aad palle;sui aq }snw JI -s;uouodwoo :suo!;elnd!;s 6uiMollo; eou oa a oa a A(asaan a ueo a6ae osi o! a soa oa a u 1un ay} qj!M palle;su! aq }snw aoeuan; ay} ' suoi;eo!ldde yons ul I } I I P y P } I `d '0. 6uiyonoJ aao;aq A;!o!aJoala oiJe;s s,Apoq a6aeyos!Q :310N seaae 031110 ao uowwo0 'sla;Ow/sla;OH `savoy 6u!sanN SN011nb'o3bd (QS3� 3J21`dHOSIQ oll`d1S0211o313 `sago;s lie;aa `sayo�ny� `s6u!pl!nq ao!}}0 `slooyOg :suoi;eo!ldde le!oaaw 'eouejejej aanlnj jol eoeld ejes a ui aan;eaaall sly; doey -woo le!a;snpu!-uou 6uiMollo;ay}ui pasn aq ueo aoeuan;s!yl -abewep uo!JeJaodsueaJ ao; -(coop 6u!}eaado ue ql!M pasoloua si eaae abeae6 ay}papiAad saaleap woa;sw!elo}dame IOU ll!m aaan}oe;nuew ao aolnq!a}s!p eaae 06eae6ao`coeds Imeao'soedsoille'-wi)saoopui palle}sui ayl 'Uu!elo yoea;o uo!Je6IISGAUi y6naogj a ao; pue abewep aq ;snw aoeuan; ayl •suoiJeo!ldde aoopJno ao; pailrpoo ao ;o uO!Joadsu! Jdwoad 6uijew ao; alq!suodsaa si aa!aaeo ayl pau6!sap J!s!J909N 'salo!yaA leuO!Jeaaoaa ao saai!eJI`savoy aligow ui asn ao;pai;!:pao ao pau6!sap lON s!}I •suo!Jeoildde aaiaaeo of paJaodaa s1 a6ewep aw!J ayJ le an!;e}uasaadaa 6u1}eay-awoy le!Juap!saa aO;pau61sap Aliaewud si aoeuan;s!yl s,aa!aaeo Aq panssi Jaodaa uo!;oadsu! aqj ;o AdoO • N0I1V017ddd 10nO0Hd -suoiJonpaa ao s;unoosip.lay;o pue apes}6u1MOgS'aoionui ayJ;o Adoo pa!;!Jaao ao leu!6!aO 3171H3n 1VNouv3a�3a ';oaaayJ nail ui Al!uwopui ao ll!q Jy6laa; pied leu!6uO tl0'H311tl111'3WOH 31180W V Ni 3JtlNUn3 SIHl11tl1SN1ION 00'3mli -puoq Al!uwapu! 01 3n0 HIM NO ANnrN11VNOSV3d'39tlWtl0 AiH3dOHd 1N3A3Hd Ol Jo 'bu!pe-1 ;o II!8 aqj ;o Adoo pal;!Jaao ao leu!6uO JNINMVMTF -suo!Je}!wil;o a;n}e}s y;uow au!u a u!yJ!M s}uawnoop Jaoddns bu!Mollo; aqj qj!M wielo aqj al!d •J? 'Aluo 6u1Ju8A I fuo6a}e0 ao;pau6!sap aae sooeuan;asayl -SAep aA!; u!yJ!M Algeaa;aad -alq!ssod se uoos -6u1;u8A pue 'suo!Joauuoo peads ao;ow pue `Vjj0 wnw!xew se pa!;iJou aq Jsnw aa!aaeo 'abewep paleaouoo 4J!M '£ Combustion and Ventilation Air In the USA,this furnace MUST be installed in accordance with • The furnace heat exchanger, components, duct the latest edition of the ANSI Z223.1 booklet entitled"National system,air filters and evaporator coils are thoroughly Fuel Gas Code"(NFPA 54),and the requirements or codes of cleaned following final construction clean up by a the local utility or other authority having jurisdiction.Additional qualified person. helpful publications available from the NFPA are, NFPA 90A • All furnace operating conditions (including ignition, - Installation of Air Conditioning and Ventilating System and input rate, temperature rise and venting)are verified NFPA 90B -Warm Air Heating and Air Conditioning System. by a qualified person according to these installation All venting shall be in accordance with the National Fuel Gas instructions Code, ANSI Z223.1, or applicable local building and/or air • Furnace doors must be in place on the furnace while conditioning codes. the furnace is operating in any mode NOTE: Furnaces with NOx screens meet the California NOx • Damage or repairs due to failure to comply with these emission standards and California seasonal efficiency stan- requirements are not covered under the warranty. dards.ANNUAL inspections of the furnace and its vent system NOTE: The Commonwealth of Massachusetts requires that is strongly recommended. the following additional requirements must also be met: LOCATION REQUIREMENTS AND CONSIDERATIONS • Gas furnaces must be installed by a licensed plumber Your unit model type determines which installation proce- or gas fitter. dures must be used. For *MEC80 models, you must follow • A T-handle gas cock must be used. instructions for Horizontal Left, Horizontal Right or Upflow • If the unit is to be installed in an attic,the passageway installations only.These furnaces are not approved for Down- to and the service area around the unit must have flow installations. flooring. *CEC80 models may be installed in the Downflow position as well as Horizontal Left& Horizontal Right positions. A WARNING TO PREVENT PROPERTY DAMAGE,PERSONAL INJURY OR DEATH DUE TO A WARNING FIRE,DO NOT INSTALL THIS FURNACE IN A MOBILE HOME,TRAILER,OR RECREATIONAL VEHICLE. TO PREVENT POSSIBLE EQUIPMENT DAMAGE,PROPERTY DAMAGE, PERSONAL INJURY OR DEATH,THE FOLLOWING BULLET POINTS MUST BE OBSERVED WHEN INSTALLING THIS UNIT. To ensure proper furnace operation, install, operate and maintain the furnace in accordance with these installation Follow the instructions listed below when selecting a furnace and operation instructions, all local building codes and location. Refer also to the guidelines provided in the Com- ordinances. In their absence, follow the latest edition of the bustion and Ventilation Air Requirements. National Fuel Gas Code(NFPA54/ANSI Z223.1)and/or local Centrally locate the furnace with respect to the plumbing or waste water codes, and other applicable codes. proposed or existing air distribution system. A copy of the National Fuel Gas Code(NFPA 54/ANSI Z223.1) Ensure the temperature of the return air entering the can be obtained from any of the following: furnace is between 55°F and 100°F when the furnace is heating. American National Standards Institute Provisions must be made for venting combustion 25 West 43rd Street, 4th Floor products outdoors through a proper venting system. New York, NY 10036 The length of flue pipe could be a limiting factor in locating the furnace. National Fire Protection Association Ensure adequate combustion air is available for the 1 Batterymarch Park furnace. Improper or insufficient combustion air Quincy, MA 02169-7471 can expose building occupants to gas combustion products that could include carbon monoxide. Refer CSA International to Combustion and Ventilation Air Requirements 8501 East Pleasant Valley section. Independence, OH 44131 The furnace must be level. If the furnace is to be set on a floor that may become wet or damp at times, The rated heating capacity of the furnace should be greater the furnace should be supported above the floor on than or equal to the total heat loss of the area to be heated. a concrete base sized approximately 1-1/2" larger The total heat loss should be calculated by an approved than the base of the furnace. method or in accordance with "ASHRAE Guide" or "Manual Ensure upflow or horizontal furnaces are not installed J-Load Calculations" published by the Air Conditioning Con- directly on carpeting, or any other combustible tractors of America. material. The only combustible material allowed is wood. 5 9 -aoeuan; ayl;o �oeq ayj o} payoelle aq aanau Isnw �ponnfona :310N suo!�elle;su!aadoad ao�aseqqns ay;y�!nn suoi�ona�sw GqI nnollo_� •poom bu!pnloui lepa;ew alq!lsngwoo •aoeuinj ayj jo pua AUe JOAO suo!lellelsu! I!un mol;ialunoo ly6iadn .Iol juawliedwoo aannolq ayj ayl of payoelle aq Isnw �jonnjonp pasn aq Isnw aseqqns fuossaooe leioadsy•(sI!ejap ujnjaj 'saoeuanjmo/pajunoo jo3 •uedaseq ayj of papelle aq jo; (apow anon( of algeo!Idde hays uo!jeomoad(z Isnw jomjonpa!eujnlaa'saoewnjmo/ldnpa!!ejsu!1f//ejuozuoq aas) aseqqns Ajossaooe ue asn 'Aiessooeu joj •uedaseq jo/pue (s)Iaued ap!s ayj of payoelle aq Aew sawooaq jooll alq!lsngwoo a JOAO uoi}elleISui 11 �ponnjonp a!e ujnlaj 'sooewn;Mo/ldn pallelsuw Alleoi}Pan J03 •aooll alq!lsngwoo a aano uo!lellelsu! nnolpa;unoo •�oeq sj! uo ooeuinj s!yl llelsu!jou o4 •umop Opp ly6!j jo 1;91 •jnoa6;uawoo ao punodwoo 6u!�lneo yl!nn AjjejuozlJOy ao (nnollunnop) A11e011Jan pallejsui aq Aew so aaggn.I uoo!l!s a 6u!sn Aq aooll pue aseq aoeujnl -oeuinj!apow 08033x•unnop ap!s Iy6ia ao 401 yl!nn Apejuoziaoy aye uaaiw}aq spew aq pinoys Teas Jy6!j y lanai pue jo(nnolldn)A11e011JGA palle}su!aq/(ew saoeuinj lapow 0803W.., y}oows s! 6u!uado ayj punoae eoejjns ay} ainsua SNOIlISOd N011d11`d1SNI '6uivado wnuald ayj JOAO ooeuinj aqj bu!flas aaolag -aooll alq!lsngwoouou a aano uoljelle}Sul nnoljjalunoO . uopein6l;uoo le;uozpoy jo}aauejealo dol •lonj p!!os uanq o} paubisap aoue!Idde ajeaedas a somas (wnN3-ld) 3-10NIS 1N3A-L9 feyl onll Aouw!yo a o; ooeuinj s!yf foauuoo jou oa dol Noea 1NON� s301s 1N3A 'aoeuinj ayj jo ap!s „wo};oq -papuaw /unnop„.Io „dol/dn„ ayj uo saoop ssaooe ayj ql!m I!un -wooaa si 6uio!naas aoj „VZ;o aoueaealo luoal palonalsgoun ayf llelsul IOU od -JeBueyoxa;eay ayf ojul AjjeIuozlaoy AIIIISISS300V ON`d S30N"V3"1C) aa!j saauanq ayj leyl os IeO!Pan aq Isnw saoop ssaooe aoewnj ayf 'Alle}uoziaoy palle}sui si ooeuinj ayj 11 -sooepns •salo!yan Aq ebewep ainsoloue ayj ap!slno aleu!waa} pue ooeuinj ayj leO!sAgd woaj eoeuinj au} ;oalad •Joojj ayj anoge of poleas Ala;aldwoo aq Isnw slonp me u.Inlelj (ww L9t,)sayOul 96 uey}ssal jou pa;eool a.Ie aoinos -uan}aa uol}!u6i pue saauanq ayl feuf os eoeuinj ayj uo!lisod op!s ao;aleld aseq p!!OS anowaa lON Oa '189010 10 'a6eieb leiluep!saa a ui pollelsui si eoeuinj ay; 11 cool; woaj „Z6 pue lasolo ;o dof woaj „Z6 aleupiaf -uoi}oaa!p awes ayf ooel;snw eoeuinj Isnw sadid Alddns iie uo!fe!iIuan/uo!}sngwoo -aseq pue I!oo ayf jo }uoaj ayj 'suo!;eo!Idde mol;dn ao3 . jo aooll of paleas Ala;aldwoo aq Isnw aoeuan_� •aoeuanj y3P!n^„8„ a y;!nn •lasolo ayj of pallelsu! aq Aew I!oo y;p!nn „O„ a :aldwex3 'ooeuinj poilddns aq Isnw ne uolIel!;uan/uo!lsngwoo alenbapy ay} ueyj aa6jel az!s auo aq Aew ao aoeuinj ay} se aan6!� yfp!m awes ayj aq Aew ooeuanj nnolpolunoo a japun ao eoeuinj nnolldn ue anoge pallelsu! I!oo a 'Alleuo!l!ppy „£-aouejeal3;uojd snu!w y;p!nn eoeuinj ueyj ssal aq jou lleys ylp!nn - I!oo bu!l000 wnw!uiw ayl 'suo!leo!Idde IeolIaan J03 •aoeuanj ay} jo peaye pooeld si I!oo I!un bu!l000 ayj j! linsai ll!m ampej aa6ueyoxa feat' ainfewaid -I!oo I!un 6uy000 ayj yl!m lalleaed ui ao weaalsdn eoeuinj ayj Ilelsu!'l!un 0 6ull000 a y}!m uoifoauuoo ui pasn si aoeuanj ay} 11 sleualew 6uigsem pine tiuosew pue aoueieala SJ@AJP SegI013 aol saaual}os oiagel oilelsi;ue aPIS sanlb pue s}uawoo ppe olJolyoapAq saysivaen o-Tee saanowaa juied „�-dol s�ul 6ul}uud (auajAgj@ojojgoaad se Bons)suoilnlos 6u!uealo Juan L-9 sulsn s}ueaa6!ajaj adAl uaboleq „j io io;oauuoo IIeM al6ulS 6ulsn„g appolgoealal uogjeo -salglisngwoo o;eauejeelo adld Juan sleolwayo ao sees 6ulolop 'aoeuin}ayl jo aa6ueyoxa sleolwayo 6uiva}}os Salem jeay ayj woaj weaajsumop aq Isnw I!oo bu!uoil!puoo sleolwayo food 6uiwwims poseq-aupolyo a!e ayl -aooll ay} pue ooeuinj ay} uo 6u!uodo a!e sJouealo.Io saxem pa;euuolyo Alddns ay} uoamleq polle}su! s! I!oo buiuoil!puoo :saoue;sgns 6u!nnollol ay}of pasodxo iie ue j! paa!nbai aq jou ll!m aseqqns ayl :310N) si a!e uo!lsngwoo ayl aaaynn ooeuinj ayj llelsu! jou •bu!jooll poonn uey;aayjo lepajew alq!fsngwoo aayfo op •swelgo.Id palelaa-aouewaojjad pue Alojes ui .Io'opl'builadjeo uo Al;owip ooeuinj ay}lle}su!jou oQ jjnsaa ll!m a!e uoilsngwoo paleu!wefuoo of aansodx3 . ,i HORIZONTAL INSTALLATION EXISTING FURNACE REMOVAL Line contact to framing is permitted when installed in the hor- A WARNING izontal configuration. Line contact is defined as the portion of CARBON MONOXIDE POISONING HAZARD the cabinet that is formed by the intersection of the top and Failure to follow the steps outlined below for each side. ACCESSIBILITY CLEARANCE, WHERE GREATER, appliance connected to the venting system being placed SHOULD TAKE PRECEDENCE OVER MINIMUM FIRE PRO- into operation could result in carbon monoxide poisoning or TECTION CLEARANCE. A gas-fired furnace for installation death. in a residential garage must be installed so that the ignition The following steps shall be followed for each appliance source and burners are located not less than eighteen inches connected to the venting system being placed into (18") above the floor and is protected or located to prevent operation,while all other appliances connected to the physical damage by vehicles. A gas furnace must not be in- venting system are not in operation: stalled directly on carpeting,tile,or other combustible materials 1)Seal any unused openings in the venting system. other than wood flooring. 2) Inspect the venting system for proper size and horizontal FURNACE SUSPENSION pitch,as required in the National Fuel Gas Code,ANSI If suspending the furnace from rafters orjoist,use 3/8"thread- Z223.1/NFPA 54 or the Natural Gas and Propane ed rod and 2"x2"x3/8"angle iron as shown below. The length Installation Code,CSA 6149.1 and these instructions. of rod will depend on the application and the clearances Determine that there is no blockage or restriction, necessary. leakage,corrosion and other deficiencies which could PROVIDE 8"MINMUM CLEARANCE BETWEEN cause an unsafe condition. CENTER ROD AND FURNACE CABINET TO ALLOW FOR CIRCULATOR BLOWER REMOVAL 3)As far as practical,close all building doors and windows 3/8"DIAMETER ASSURE FURNACE IS LEVEL FROM and all doors between the space in which the THREADED ROD \ END TO END AND HAS A SLIGHT appliance(s)connected to the venting system are located (6 PLACES) FORWARD TILT WITH THE FRONT '\ OF THE FURNACE V-3/4" and other spaces of the building. BELOW THE BACK OF THE FURNACE 4)Close fireplace dampers. NUTS HOLD DowN r y!SUPPORT 5)Turn on clothes dryers and any appliance not connected I NUTS to the venting system.Turn on any exhaust fans,such as range hoods and bathroom exhausts,so they are operating at maximum speed. Do not operate a summer exhaust fan. 2"x 2^x 3/8" � 6) Follow the lighting instructions. Place the appliance being ANGLE IRON TILT OUTWARD TO ALLOW FOR POSITION AS CLOSE AS POSSIBLE inspected into operation.Adjust the thermostat so (3 PLACES) TO BLOWER DECK TO ALLOW FOR DOOR AND CIRCULATOR BLOWER p p CIRCULATOR BLOWER REMOVAL REMOVAL appliance is operating continuously. 7)Test for spillage from draft hood equipped appliances at Suspended Furnace the draft hood relief opening after 5 minutes of main Figure 2 burner operation. Use the flame of a match or candle. 8) If improper venting is observed during any of the above tests,the venting system must be corrected in accordance with the National Fuel Gas Code,ANSI Z223.1/NFPA 54 and/or Natural Gas and Propane Installation Code, CSA B149.1. 9)After it has been determined that each appliance connected to the venting system properly vents when tested as outlined above, return doors,windows, exhaust fans,fireplace dampers and any other gas-fired burning appliance to their previous conditions of use. 7 8 -aoeuanj (uoi;sngwoo pa/eas `-a-/);ueA;oe-qp a se pa//e;su/ -sapo0 uOl;ellelsul 6t68 VSO/NVO eq/ouueoI/ -uqqsngwooaoj./ejoopu/asn;snwooeuanjs/gl aO/pue 1,TZZZ ISNV/175 VddN apon seE) land leuol;eN ay; -saOuelld ;o uol;lpa }sa}el ay; glInn eouepiome ul eq ;snw suoi;oaijoo -de ayj ao; sjuawaalnbaa ale uollsngwoo ayj 6uiuiwaajap ao; sopoo bulpllnq leOol au; ;o suolslnoid algeoildde ao sopoo lel}lui uollellelsul 6b68 VSO/NVO aO I,'£ZZZ ISNV/bS VddN WOE jeja anal suep slwaj a.I;a Juanlop zeg ne sa}uawlle seE) land leuogeN ay};o uol;lpa;sMIRI GqI o;aa;a�] •seouelld uol snywoa ap sllaaedde sailne sal snob ja j@Aoj ap -de Ile JO;ale uol;ell;uan pue uol;sngwoo;o Alddns a;enbope sa.Ilslgaa sal `s.lnanelljuan sal sa.Ijaua;sal 'saliod sal ue sl away; oinsue `aa;eay aa}em a se yons 'saouelldde se6 'snssap-la sl!j:)ap slessa sap uaAow ne juawajaa.uoa jay;o y}lM coeds awes ay; ul pollelsul eq o;sl ooeuin; sly;;l auuol}auo;uoljelljuan ap awalsAs ne apaoaaej 'aplxouow uogaeo Ilaaedde anbeya anb aulwaalap a;a a Il,nb slo;aun (6 opnloul pinoo;ey;slonpoid uol;sngwoo se6 of sluedn000 bul •T•61vT8 -plinq 6ulsodxe Agejoy; 'saouelldde pajl;-se6;o uol;sngwoo VSJ`auedoad np Ia lainieu zeg np uogelle}sul,p apoD ne aadoidwl ao bul;;eap Veq asneo ueo uol;ezimssaidep asnOH (no)}a VS VddN/T'£ZZZ ISNV'apoD seg land leu011eN ne ;uawaw.lo;uoa u011e1lIuan ap awalsAs ne saliodde aaja •ale ao;saouelldde bulnaels Aq walgoad ay;eseaaoui juanlop s;llaaa,Ioa sap 'snssap-la sjuaap slessa sap un,l ('o;a 'sooeldaal; 'sue; ;sneyxo 'siefup say}olO) asnoy ay; ;o juepuad aAAasgo Ise uolIell;uaA ap awalgo.ld un IS(g ;no ale Ilnd ;ey} seouellddV saouelldde buluanq len; aay;o •algnoq aun,p no allawnlle aun,p awwel;el pue pawl; se6 ao; .Ile uol;elljuaA pue uol;sngwoo 6uiAlddns aasmin •ledluulad inaln.Iq np juawauuoljauo;ap salnulw walgoad a pa;eaao aney ;nq s;soo 6ull000/6ul;eay 6ulonpaa S Saade salop luos ua lnb sllaaedde sap agealj-adnoa np ul podlay aney sa6ueyO asayl 'snnopulnn pue scoop puno.Ie aanl.Ianno,l ap neanlu ne ailn;ap aauasaad el Jal;laaA(Z odeose pue uoljejIlqul ale 6ulonpaa Aq ssol;eay poonpaa aney •nul}uoa ua auuol;auo;IIa.ledde,l anb as a a.Ialuew ap s6ulpllnq ul uol;elnsul leuol;lppe pue uol;on.gsum panoadwl jejsowaayj al aalgaa uolpadsul l e slwnos llaaedde l ayaaew ua ajjIaA @Sewnlle,p suollanalsul sal WAlnS(9 'V3HV TMun3 3H1 O1N1 031lddns 'clap sina}ellIuan sal ayaaew ua a.1IIaw 38 HIV 301s1nO 31Inb3H S3WOH BOW -a31lddnS 38 ism S3SV9 3nu sed aN •alewlxew aauesslnd el a aalgaa sal ja`suleq d0 NOUVlI1N3A 0NV Nousnum)H3dOHd Hod HIV HS3Md 1N3171d3ns ap salles sap Ia aulslna ap saj}oy sap lnlaa awwoa'aseill 'H1V30 HO AHnfNI IVN0SH3d'39VWV0 A1H3dOHd 01OAV Ol ap s.Ina}ell;uaA sal sno}ayaaew ua ajuaA •uogell;uan JNINZIVM V ap awalsAs ne sapaoaaea sed luos au lnb sllaaedde sailne sal snot anb lsule ayaaew ua sasnayaas sal aillaN (S S1N3W-98inb3a 21/d 'sjaAo;sap aalslga.l al jawaad (b •juawlleq np sauoz sailne sal p uol;ellluaA N011V711N3A ONV N0I1S(19W0o ap awalsAs ne sapioaae.I sllaaedde sal Juannoal as no }lo.Ipua,l lueaedas saliod sal salnol anb lsule;uawl;eq •suol;neowd aaq:pn; pue suol;on.gsul bul;unow np saa}aua;ja saliod Sal salnol jaw.1a;'alglssod IS(£ ao; ;e;sow.Iay; ay; y}lnn pa6eNoed suol;on.IIsul ay; ;lnsuoo -asna.Iaguep uol;en}ls aun.Iauieilua lualea.Inod lnb sawalgoad sailne,p Ia uolso.uoa ap'alln; lleAn apls;no ue ap`uollalalsaa ap no uollanjlsgo,p sed a A,u Il,nb aal;laaA se yons';e;sowaay;ay;pulyaq seaae pauol;lpuooun •suollan.alsul saa a 10 T'6bT8 VSn 'auedoad np ja laanjeu -sAc)uwlyo jo `sadld aa;enn plop ao}oy poleaouoo zeg np uol}elleisul,p apon np no 175 VddN/T'£ZZZ ISNV -aoeldaal; a woe;}eay}uelpe�j 'apon seg land leuolIeN np saauaglxa xne saw.Io;uoa saouelldde aay}o ao sawn;xl;;y6l� juOS alejuozuoy,l a j.Ioddea jed uosleullaul,l Ia alllel el lS Jal;laaA ap idle uol}ellJuan ap awalsAs al aalaadsul (Z 'uns ay; woa;;eay;uelpe�j •uoljellJuanap •sialsibei wa;jle ploO aO 10H awalsAs np saaslll}nul sa.In}.Ianno sal sainol jallaa5(T 's}aulgeo japun .ayaaew ua sed luos au uoljelljuan ap awaIsAs ne sapaoaaea jo 'saauaoo ul `scoop pulyaq sods peep jo `s}}eaa sllaaedde sailne sal snot anb saole 'ayaaew ua aslw es ap :bulnnollo;ay; 3uawow ne u011ell}uaA ap awalsAs ne sapaoaaea sllaaedde ;o Aue Aq peouenl;ul aq Aew ;l ajegm ;e;sowaay; ay} Ile}sul sap unaeya lnod salnlns a.Ija Iuanlop Sajuenlns sade}a }ou oa 'llenn aplsul aaa;-uolleaglA a uo gbly }aa; anl; ;noge sal -i.Iow el no auogaea ap apAxouow ne uollealxo;ul ;e;sowaay; ay; a;eOol `uo.IelnOalo ile pooh 6ulney eaae ue ul aun aauie.Ilua}nad elaa'ayaaew ua aslw es ap juawow ne uolIellIuan ap awalsAs ne sapaoaaej sllaaedde sap unaeya NORV001 1V1S0W213H1 inod salnlns sed duos au snossap-la sa}ljaap sadeia sal 1S 'VCZZZ ISNV apoO SEE) land 3N08HVJ 30 30AXONOW nV N01MIX01N1,0 Mosib leuol;eN ay;;o uol;lpe Iselel ay; ul eIge; ejeudoidde ay; asn 1N3W3SS11U3AVTF 'wa;sAs 6ul;uaA ay;;o uolpod Aue uo paalnbei sl bulzlsaj ;l -j Most homes will require outside air be supplied to the furnace THIS PRODUCT IS NOT DESIGNED FOR COUNTER- area by means of ventilation grilles or ducts connecting directly CLOCKWISE INDUCED DRAFT BLOWER ROTATION. to the outdoors or spaces open to the outdoors such as attics or crawl spaces. Vent the furnace in accordance with the National Fuel Gas CATEGORY I VENTING VERTICAL VENTING Code NFPA 54/ANSI Z223.1 - latest edition. A WARNING Venting TO PREVENT POSSIBLE PERSONAL INJURY OR DEATH DUE TO THIS FURNACE IS NOT DESIGN CERTIFIED TO BE HOR- ASPHYXIATION,THIS FURNACE MUST BE CATEGORY I VENTED. DO NOT IZONTALLY VENTED. VENT USING CATEGORY III VENTING. To rotate the Induced draft blower clockwise, you will need to purchase one(0270F01119)chimney transition bottom kit. Category I Venting is venting at a non-positive pressure. A 1. Disconnect electrical power from the furnace. furnace vented as Category I is considered a fan-assisted appliance and the vent system does not have to be "gas 2. Disconnect the induced draft blower power leads, flue tight." NOTE: Gas furnaces with induced draft blowers draw Pipe, and pressure switch tubing. products of combustion through a heat exchanger allowing, 3. Remove the round cutout from the right side of the in some instances, common venting with natural draft appli- wrapper. ances (i.e. water heaters). All installations must be vented 4. Remove and save the four screws that fasten the in accordance with National Fuel Gas Code NFPA 54/ANSI induced draft blower to the flue collector box. Z223.1 - latest edition. 5. Remove and save the three screws that hold the NOTE: The vertical height of the Category I venting system chimney assembly to the induced draft blower. must be at least as great as the horizontal length of the venting 6. Remove and save'the four screws that fasten the system. chimney top to the chimney bottom. AWARNING 7. Remove the chimney transition bottom from the transition bottom kit. TO PREVENT POSSIBLE PERSONAL INJURY OR DEATH DUE TO 8. Install the chimney top with the four screws retained ASPHYXIATION,COMMON VENTING WITH OTHER MANUFACTURERS from step 6 onto the new chimney transition bottom INDUCED DRAFT APPLIANCES IS NOT ALLOWED. from the transition bottom kit. 9. Install chimney assembly with the three screws retained The minimum vent diameter for the Category I venting system from step 5 onto the induced draft blower. is as shown: 10.Reinstall the induced draft blower rotating it 90 degrees MINIMUM VENT clockwise from the original upflow configuration using MODEL UPFLOW COUNTERFLOW the four screws retained in step 3. Ensure the gasket 060 4 inch 4 inch located between the induced draft blower and the 080 4 inch 4 inch collector box is rotated accordingly. 100 5 inch 4 inch 11. Reconnect the induced draft blower power leads. NOTE: If the wires are not long enough, pull extra wire Under some conditions,larger vents than those shown above from the wire bundle in the blower compartment. may be required or allowed. When an existing furnace is re- 12.Reconnect the flue pipe,and the pressure switch tubing. moved from a venting system serving other appliances, the Ensure that all wires and the pressure switch tubing is venting system may be too large to properly vent the remaining at least one inch from the flue pipe, or any other hot attached appliances. surface. Furnaces are shipped with the induced draft blower discharg- 13.Restore power to furnace. ing from the top of the furnace. ("Top" is as viewed for an upflow installation.) The induced draft blower on *MEC80 Counterflow units are shipped with the induced draft blower models can be rotated 90 degrees for Category I venting. For discharging from the top of the furnace. ("Top" as viewed for furnaces installed vertically or horizontally, a four-inch single a counterflow installation.) wall pipe can be used to extend the induced draft blower Vent the furnace in accordance with the National Fuel Gas outlet 1/2" beyond the furnace cabinet. On*MEC80 furnaces installed upflow or horizontally with left side down, the draft Code NFPA54/ANSI Z223.1-latest edition. inducer may be rotated to discharge from the right side of the A WARNING cabinet.When rotating the inducer a chimney transition bottom kit(part#0270FO1119) is needed for proper alignment of the NEVER ALLOW THE PRODUCTS OF COMBUSTION,INCLUDING CARBON inducer outlet and the vent exit hole in the side of the cabinet. MONOXIDE,TO ENTER THE RETURN DUCTWORK OR CIRCULATION AIR The inducer may NOT be rotated on*CEC80 model furnaces I SUPPLY. regardless of installation position. 9 M -.lelloo ang ao;alJno pooy Jleip Juawdlnba waJsJ(s 6uiJuan aoeuinl ay; paJoauuoo ;say61y ay; anoge Joel GlAg ;seal Je pua;xa ;snug to uol;oadsul �(l�ea�( e w�olaad o;;sgi{oayo sly;asn uewaoln AOUWIyo ayl•;aal p 6 ulyJlnn paJeool Jalui pie pao.lol AUe anoge -aas pallenb a JeyJ puawwooaa an `uo;ppe ul (auwlyo Joel E Jseal Je a;euwaaJ Jsnw Aauwlyo ayJ`UOI;IPPe ul -Joel 0 Ajuosew a o;ul aoeuinl +09 ue bulJuan ajolaq po�oayo lo aoue slP Ia uozio 4a ui4;In Buippq e jo uorpod (ue ueyJ aq of swell ay;to Ajewwns a se somas;spoayo siyl jay6ly Joel oAq Jseal le pua;xe;snw Jl •looa ayJ y6no.ly;sassed JI a.Jaynn Julod Jsay6ly ayJ anoge;aal eejgl Jseal le pua;xa;snw AavwwnS 1snN33HC) Juawdlnbe paall Safi aol Juan a se pasn Aeuwiyo fijuosew y s ain6ld Aeuwi40 alll Re10 anl.1 aIdRInW lealdA.L 'NOIl`VNIWa31 A3NWIH3 H3dONd - NO3HO JOo131uawaseg L, -OA*:IVA InO uealO (L�loa40).u0I}elle1sul iopauuoOluoqaq}ajaldwoo �eleeHiamM- JOOIJ lSJl3 J0013 pumas (b x!d) (9�ioa4o) awla�l oN Lalgellene JIe uoilnll(i a.eds!V..L.1.ZIL 1 JOOIj aI11V SaA (41Bua1..VZ x 4ae3) .ZLx"sx„Q:az,s-ILL 6e1p `Q6�ol„bZ)„ZL x.ZL (ti xu) (9�loa4�) (w euon ens a�!l A.10 ouila� ON �uol1lpuoo pooh ul Joull :,�\ gseM� umop '1N3AIVJ3W 8 3dU7dO Id3N111VI3W(I3ZISAIJ33d011d J30HAVMHMd VSVA3NWIHaAIANOSVW sijgap 9NIsn Au U3UIOnV 1S39 SI 39VW VU NOIIVSN3UN0a JO NSIH 3H1, (b x1j) (b ) auila�{ oN (,SIJgaP 'SNOIIIU NICK)353H13oNOIlVN19WOJANV]iO r SA3NWIH9J3OI>i3JX3 jo aaJl 1nouealo `SH0193 NNO}1N3A 9NCFI`SNOII1U NOa U1O9 A13 W3J3JJf3 H11M 1SIX3 11IISAVW 39VWVU NOIIVSNMN CIO 130d IVIA310d 3H1`39NVnddV A \' U3ddIni3U00H JdVN(3 V H JAM U31N3A NOW WO9SI 3wNJ3n3 F'i,m saA NV 31 'S319V1 9NIA31A 31V17ddOdddV 3H1 H11M 3.aNVUHO'J9'IJ' NI U3ZIS 3915nW SA3NWIH-aAJ3NOSVW 4NisnSN011VIIVISNI11V-1N3AIV13A (17 XU) (g�loay�) 0 3,:! , IdOHNIIIVI3W V HIIMU3NII SI A3NWIHa3Hl11033NVnddV aulla�lJo/pue ON U01}IpU00 U3ddIn03U00H13VIP3VH-LIMU31N3ANOWWO3SI3aVN21n3 (E xij) pooh ul tim0io uMoJoplingeH 3H1.MINnA3NWIH9AldNOSVW VO139VNJ3n3'%(}$NV193NNO:3 10N OQ 'HIV NOI.LmIU 31Vn-03UV1nOH11MU31N3ASl (33VNJ3n1 3 fjV 9 Mj 3JNVIIddV I A7d0931V3 031SISSV-NV3 31DNIS V N3HM SPA SA3NWIH?AldN0SVIN 3UISN1 Hn73'0 NV9 NOIIVSN3UNCO 9NIDVWVU H1V310 Ho Aid nFNIIVNOSH3d `39VWVU.U.113dO7dd 20.U.11191SSOd (Z�09go) O N I N21'dJNk v (Z x!d) 6saoueildde sjuawa6mie ON an inbl Buguan 96ueg0 — pue pij s to 99ij -aaull ollleJaw pezls Apadoid a aimbei 11p lauuego I(auwIg0 sAE)uwlyo tiuosew buJJsixa ay;`suolJenJis;sow ul 6ul;uan10 odAj sigj to Al!llgeJlns a4l uo ;oedwl J0eJlp a aney sainJejed L -waJ u6lsap .laJUIM 9141 1e41 paaanooslp aney sJayo.leasa�:l saA U0IJelle;sul ay; to uol;eo 1 ol oiydej6oa6 aqj sl algei�en s14 sAauwlgo JolJaJul yJIM pa;eloosse;ou ja;aweaed a uo spuadap (6 xl=) 4 moa4o) Aauuug3 Ajuosew paull Aelo a asn of Allllge eqj „•cull looa deo 111.119n P91SH oN �UoljeulwJal ay;nnoloq sops aaow ao ouo uo sioopJno ayJ of pasodxa Aeu ql!m ejeulwiel'aui1 Aouwlgo JadOJd -wlyo,,AjuoseVy,,a se paullap sl Aauwiyo fuuosew aolja;xa uy •wel! yoea yJIM peouaaalaa (A7NO S3ob'N2N)j i AH0931Vj) ydeibeied aqj aas 'pouol;uaw sainp000id aqj to yoea uo u01Jewi0jul palle;ap aoj -fuewwns a Aluo sl Jspoayo slyl SA3NWIHD AHNOSVMI 80/2I31X3 1 If the chimney does not meet these termination requirements, Liquid fuel appliances include oil furnaces,oil-fired boilers and but all other requirements in the checklist can be met, it may oil-fired water heaters. be possible for a mason to extend the chimney. If this will not be practical, see Fix 1. Appliances which burn propane(sometimes referred to as LP 10'or L (liquefied petroleum))gas are considered gas-fired appliances. 4 —I CHECK 3 - CHIMNEY CROWN CONDITION. 2'Min. 2'Min. I I I I t I 13'Min. Damage from condensate usually shows up first in the crown. I l f I I If any of the following trouble signs are present, the condition I I l of the crown is not satisfactory: I I JTa1.1ora) Crown leaning pet JVVILI I b) Bricks missing / c) Mortar missing Chimney J Figure 4 d) Tile liner cracked 10'or Less e) No tile liner .— f) Salt staining at mortar joints. (White stains, and mortar j�I becomes sandy and/or erodes.) 2'Min. I I t For problems a, b, or c, see Fix 3. If problems d, e, or f are Ridge t I I T Min. present,see Fix 4. IMPORTANT: It may be necessary to follow both Fix 3 and Fix 4. I I I I CHECK 4 - DEBRIS IN CLEANOUT. I I Chimney— I A cleanout(dropleg)must be present such that the upper edge of the cleanout cover is at least 12 inches below the lower Termination 10 Feet Or Less From Ridge,Wall or Parapet edge of the lowest chimney inlet opening. Figure 5 .4--More than 10'� A chimney without a cleanout could become partially blocked by debris. If no cleanout is present, the chimney must be I I f relined (Fix 4). Remove the cleanout cover, and examine I I s Min. the cleanout for debris. If significant amounts of any of the I l following are found: I I I I Fuel oil residue NOTE:No Height Bricks above parapet required when distance Chimney Mortar or sand Wall or from walls or parapet is Parapet more than 10 feet. Pieces of the tile liner Figure 6 Rusted pieces of the metallic liner-reline the chimney (Fix 4). 4 More than 10'-► Height above any roof surface within CHECK 5 - LINER CONDITION. �10:: 0 feet horizontally If a metal liner is present, it must be checked. It cannot be Ridge assumed that all existing metal liners are correctly installed 2"Min.f 1 and in good condition. I I I i j3'Min. Remove the lowest existing vent connector, and examine the inside of the elbow or tee at the base of the liner.A small amount of soot may be considered acceptable, provided the Chimney—i I installer vacuums it away. If rusted pieces of the liner have collected here,the metal liner must be removed and replaced Termination More Than 10 Feet From Ridge,Wall or Parapet (Fix 4). Figure 7 Next, gently tap the inside of the liner with a Phillips screw- CHECK 2 -ANY SOLID OR LIQUID FUEL APPLIANCES driver. If the screwdriver perforates the liner, or if the tapping VENTED INTO THIS CHIMNEY CHANNEL does not sound like metal hitting metal, the liner must be removed and replaced (Fix 4). Solid fuel appliances include fireplaces, wood stoves, coal furnaces, and incinerators. Remember that all appliances must be vented inside the liner. Venting one appliance inside the liner and another appliance outside the liner is not acceptable. 11 ZI. '66Z VddN/ISNV's@ouellddV buluing /NVO PUe V6b68 VSD/NVO'epeuBO Jo piepueJS leuol}eN ay} land plloS pue`sJuan`saoeldaJld `sftauwlgo Jol piepueJS ay} ul pue uolJlpa Jsa}el - V£ZZZ ISNV/t g VddN apoo set land sl peouaaa}aa aq stew yolynn piepueJs yons auo •spiepue}s Jo leuol}eN ul salgeJ ay} Aq paulwj@lap se azls alge}daooe ue sapoo BulPI!nq pazlu600aJ Alleuogeu y}inn eouepi000e ul J!aged sl Jaull ay}pue 'AJo}oe;slJes uaaq aney g y6noJyJ 1, s�0047 JI -aJ @snw uosew palJ!lenb e 'pa6ewep sl unnoJo Aeuwlyo ay;dl 'NOIlVIIdlSNj 3H1 3131dW03 - L li33HO NMON3 3Hl mine3M - £ xI.1 .(t,xld) paullai aq Jsnw Aeuwiyo ay} 'algellene aq IOU ll!M ile -adid Ond gbnoay;AlleolJJan Jo Alle}uozuoy uol}nl!P JI •iadwep Juan a apnloul IOU saop JOJoauuoo Juan pa}uan aq ueo ooeuinj+%06 ayl•aoeuiN%08 ue uegl JayJeJ s,aoueildde ay}J! Aluo aouelldde J}eap lein}eu a}o pooy 4eip polle}sul aq pinoo ooeuinj +%06 e 'suolJ!Puoo awos Japun ay} gbnoJyJ poule}qo aq Alpeulpio ueo ile uolJnl!P JualolgnS •Juan g e qj!M AlleolJJan pa}uan aq of siodwep Juan gl!nn saouelldde J}eJp lein}eN paau Aew eoeuinj ay}`leolJoeid sl suolJdo anoge ay}Jo auou}l saouelldde J}eip paonpul •anplsaJ I!o :y6noJyJ paule}qo aq Jouueo ile uol}nl!d lan}aqj anow@J of pauealo aq Jul}snw Jaull all}ay} '(s)aoue -!Idde pall}-se6 Aq paoeldaJ buieq aJe(s)aouelldde pej4-I!o Jl -paimbei sl Jle uol}nllp}o aoinos e `Jaull @I!J Aelo a o}ul pa}uan aq of aJe saouelldde pail}-se6}I •paleas AlJuauewiad aq uayJ Jsnw 6uluado aoeldaJi}ayl•dnpllnq a}osoaJo anowaJ o}pauealo aq WV NOIInIIQ - 9 )�33H� Jsnw Jaull all}ay} 'os 11 •(aouelldde lon} pllos) ooeldailj ay}}o •(t,xld)pouwlaJ aq Jsnw Aeuwlyo ay}uagj'96Jel ooJ Jo flews ooJ asn anul}uoosip of awBe Aew Jaunnoewoy ay} `AIanlJeuiaJlV sl Jaull ayJ JI 's}uawpuawe pue suolJ!Pa Jsa}el - Z'6-V68 VSO •Jaull ay}ap!sJno p91Uan saouelldde /NVO PUe 6'6tiL8 VSD/NVO 'epeueo Jo piepueJS leuolJeN iay}o yJ!m Jaull Ie}aw a}o aplsul eoeuind +08 ue Juan Jou od ayJ ul pue uolJ!pa Jsa}el - VCZZZ ISNV/tS VddN apoo seE) •(s)lauueyo Jay}oue o}ul (s)aouelldde lon} pinbll Jo pllos ay} land Ieuol}eN ul salgeJ ayJ Aq paysllge}sa azls wnwlulw ay} Juan pue Iauueyo auo o}uI saouelldde se6 ayJ Juan of alglssod se @Biel se Jseal le aq Jsnw Jaull ayl •Jnoueolo aqj woJj sigj aq Aew J! 'lauueyo auo uegj aiow sey Aauwlyo Ajuosew aqj Jl op of alglssod aq Aew Jl iaull ay}Jo azls aqj ainseaw 'JxaN S1N3W39Nt 11V 9NIIN3A 39NVHo- z xI=1 '(b xld) Aeuwiyo aqj auilaJ ap Aelo ail} panoidde ue uegj JagleJ adid a6euleip Jo adid Jannas jo asn •�xld aas `6ulullaJ uo uol}ewioJul JayJJn�Jod suolJoas al!J uaamlaq woJ} buwpnJ}oid Je:poVy •�(auwlyo �(Juosew a !M aJinbaJ a none ue Jaul a !M a lssod sioJoauuoo yJ P q PI yJ I yJ Iq aq Aew JooJ ayJ anoge uoisua}xe JaJJoys a `seseo awos ul Juan Jo Jnoueelo ayJ le 96euleip ejesuapuoo Jo subiS . •suolJonJJsul s,JainJoe}nuew ay} yJIM suolJoas ap ueann}aq sdeE) aouepJ000e ul jOOJ ayJ anoge aJeulwiaJ uayJ Jsnw Algwesse bulsslw suolJOas el!1 }ow/deo pue Jaull aqj-asn yons Jo}JainJoelnuew Jaull aqj Aq pou6iles1w suolJoes al!1 panoidde aq}snw Jauil a y}!M pasn Algwesse Jooi Jo deo AuV :Juasaid aJe swelgoid NOIIVNIWN31 a3N11 - � xl j bulMollo}ay}Jo Aue}I •Jaull ap Aelo aqj Joadsul of JoJoauuoo Juan Jo Jnoueelo aqj le JoJJIw hews pue Jy61lySel} a asfl •(t7 xld) poullai aq Jsnw Aauwlyo ay} 'walgoid e Juasaid of AI@l sl sioJoeJ anoge aqj}o aiow Jo auo 'sapoo '(�xld) Paull aq Jsnw�(auwlyo aqj Jo !I leool Jo/pue'Jape}sul 'Aj!I!Jn seB leool aqj}o Juawbpnf aqj ul 'Jl Juasaid aq Jsnw Jau!I ap Aelo a `Juasaid Jou sl Jau!I leJaw a dl (•sAauwlyo Jolia}ul awnsse a •solni pue salgeJ yl/�ly`J yJ ash paneJsul aq of saouelldde aqj JoJ azls Joaiioo s}uawpuawe pue SWIPE)Jsa}el-Z'6b1.8 VSO/NVO ayJ sl Jaull Ie}aw aqj Jegj wJlJuoo 'AlleUld •(t, xld) paoeldaJ PUe V6t68 VS0/NV0 'ePeue0}o pJepueJS IeuolJeN pue panowaJ aq }snw Jaull le}aw ay} 'Juasaid aJe saloy Jo ayJ ul pue uolJlpa JS81e1- 6'£ZZZ ISNV/bS VddN aPOO sde6 Jl •punos AlleolsAgd aq }snw Jaull aqj}o sooe}Jns ayl set land leuol}eN ul salgeJ ayl) sAauwlyo Jolia}x3 dieys aq Aew siaull alq!xal;}o sa6pa Jno aqj se 'slyJ Bulop (•Joa}ap uaynn uogneo asn -lees do} ayJ J!JaJ pue 'gl6uol Jaull ssaoxe of 11nol4lp aq ueo slyJ `eol}oeid ul) •sloliq ayJ pue ayJ J}o Jno pue do llnd :leas doJ ay}Neaiq `slyJ op of •BunyaJ Jaull aqj tioemlag deb ile ou pm sAouwlyo AjuoseVN aq pinoys Jl uol}!puoo pooh ul pue Aauwlyo aql ul poleJlds sl siOJoauuoo Juan Buo- J!}I •}yBlea}s AlJeeu Jo Jy6leJ}s Buny aq pinoys siaull olq!xald JayJeann ploo Alaw8Ax3 •aiay Inidlay aq :Juan a se asn Jo}alge}!nsun Jaull ap ay}JapuaJ Aew yolynn Aew do}s ail;Jo algwlyJ V•alge}daooe aq of se os bunyaJ aq sJOJoe}6ulnnolloJ ayJ pulw ul deal}snw Jalle}sul ayJ'JanannoH Algegoid ueo J! 'IOU sl J!}I 'Jaull all}Jo sllenn Aeuwlyo ayJ Lpm •saouelldde se6 ayJ Jo}Juan a se pasn aq Algegoid ueo iaull ep Joe}uoo Jowip o}ul awoo IOU of se os pe:poddns aq}snw Juan Aelo ayJ uay} 's}u@wpuawe pue suolJ!pa ISOM - Z'6ti68 VSo 9 •Jaull aqj do Jy6ls of JoJJIw llews pue Jy6llysel a asn `JxaN Fix 4 - RELINING The vent connectors used are very long or have a Relining options include B vent and flexible liners. large number of elbows. • Local experience indicates that flexible liners installed If the chimney has diagonal offsets, B vent probably cannot without insulation are likely to have condensation be used. problems. If B vent is to be used, it must be supported adequately. Insulation must be selected and installed in accordance with Supports (such as fire stops or thimbles) must be used to the liner manufacturer's instructions. prevent the B vent from coming into direct contact with the tile liner or chimney walls. Direct contact would result in higher Finally,cap the chimney and terminate the liner in accordance heat loss,with an increased possibility of poor venting system with the liner manufacturer's instructions. performance. ELECTRICAL CONNECTIONS It is not acceptable to vent one appliance inside the B vent and other appliances outside.The excess space between the ©WARNING B vent and the chimney walls must be covered at the top of HIGH VOLTAGE ! the chimney by a weatherproof, corrosion resistant flashing. TO AVOID THE RISK OF ELECTRICAL SHOCK,WIRING TO The B vent should then be topped with a listed vent cap.The THE UNIT MUST BE POLARIZED AND GROUNDED. listed vent cap will, when installed per the manufacturer's in- structions, prevent problems due to rain,birds,or wind effects. A WARNING A B-vent installed as described in this section is considered to HIGH VOLTAGE ! be an enclosed vent system, and the sizing tables in National Fuel Gas Code NFPA 54/ANSI Z223.1 - latest edition and in TO AVOID PERSONAL INJURY OR DEATH DUE TO the National Standard of Canada,CAN/CSAB149.1 and CAN/ ELECTRICAL SHOCK,DISCONNECT ELECTRICAL POWER CSA 6149.2-latest editions and amendments may be used. BEFORE SERVICING OR CHANGING ANY ELECTRICAL WIRING. If a flexible liner is to be used, it must be made of the proper materials: A CAUTION • For most residential applications, an aluminum liner should be acceptable. LABEL ALL WIRES PRIOR TO DISCONNECTION WHEN SERVICING Flexible liners specifically intended and tested for CONTROLS.WIRING ERRORS CAN CAUSE IMPROPER AND DANGEROUS gas applications are listed in the UL "Gas and Oil OPERATION.VERIFY PROPER OPERATION AFTER SERVICING. Equipment Directory". (UL Standard 1777). For sizing of flexible liners,see the tables in the National Fuel A WARNING Gas Code NFPA 54/ANSI Z223.1 - latest edition and in the HIGH VOLTAGE ! National Standard of Canada, CAN/CSA 13149.1 and CAN/ TO AVOID THE RISK OF INJURY,ELECTRICAL SHOCK OR CSA B149.2 -latest editions and amendments. DEATH,THE FURNACE MUST BE ELECTRICALLY GROUNDED IN ACCORDANCE WITH LOCAL CODES OR IN To install the liner, read and follow the liner manufacturer's THEIR ABSENCE,WITH THE LATEST EDITION OF THE instructions and your local codes. Excess liner length should NATIONAL ELECTRIC CODE. be pulled out of the chimney and cut off. Use caution when doing this, as the cut edges of flexible liners may be sharp. Do not spiral excess liner inside of the chimney. Support the A WARNING liner as recommended by the liner manufacturer. EDGES OF SHEET METAL HOLES MAY BE SHARP.USE GLOVES AS A Some manufacturers of flexible liners offer an insulation PRECAUTION WHEN REMOVING HOLE PLUGS. sleeve designed to be added to the liner before it is installed in the chimney. (Poured insulation, either vermiculite or other WIRING HARNESS materials, is no longer recommended.)Insulation will need to be added to the flexible liner if: The wiring harness is an integral part of this furnace. Field • It is required by the liner manufacturer's instructions. alteration to comply with electrical codes should not be re- The previous liner was properly sized and installed, quired. Wires are color coded for identification purposes. and suffered from condensation damage. Refer to the wiring diagram for wire routings. If any of the • It is required by your local building codes. original wire as supplied with the furnace must be replaced, it must be replaced with wiring material having a temperature Even if none of those three conditions exist which require ad- rating of at least 105' C. Any replacement wiring must be a ditional liner insulation,the installer may wish to consider it if: copper conductor. • The local climate is very cold. • The chimney is very tall. 13 IV I, •amen se6 04}o} abewep}uauewaad asneo osle ueo uwnloo Ja}eM segoui E I.}o •aoueua}u!ew Ja4}O JO lenowaa ssaoxe ui saanssaad se0 -ainlle}j96uegox9 }eaq ain}ewaid .181111 QAA aouaaaJla}ul p!OAe o}saalM 06e1I0n MOI a4}a}noa `uo!} u! }Insaa ueo aoeuan} a4} ;o 6uui}a9np -a}eld bui}ej a4} uo -oun}lew }uawdinbe alq!ssod pone of :310N 1NV.LH0dW1 umogs }ndui pa}ea a4} poeoxa }ou }snw saauanq a4} o} }ndui se0 uol}!u6i algeilejun o}peal pinoo elge}anoge ay}u!s}!call 'aOueua}ulew J94}0 aO lenowaJ Ja}I!}4}!M aaa:la}ul IOU a4} Molaq ainssaid Alddns wnw!uiw a4} 6ugsnfpV :310N II!M uo!}eool 6uuIM}e4}wa1}uO0 OSIV'uel a4}}o uOl}e}oa a4} Aq ao saauanq a4} woaj }ea4 Aq pabewep aq }ou II!M }! }e4} wa11uO0 •6uuIM a4} }O uO!}eool 941 �10G40 .t, 3'M„0 g� :wnw!xelM 0 M„0 ( � :wnwiullnl set auedoad 'Z da}s ui panowaJ sMaaos a4} buisn 0 M„5 aoeuan} a4}to apis }}al ay} o} xoq uoi}ounf a4} 4oe}}V •E •o•M,,0.06 :wnwixeVy :wnw!uiVy IseE)lein}eN 321f1SS321d A1ddf1S SbJ 131NI 'aoeuan}a4}}o ap!s}46u a4}o} xoq uoi}ounf a4}6ulplo4 SAnaaos a4}GABS pue anowa�l 'Z •poonpoa}ui uaaq se4 sugap ao ja}emp eoelda�t{ •polle}sui si ouil -aoeuan;a4}waaj sjoop 4}og anowa�j •I, se6 94}aaojaq 6nld Jilin amen se6 94}anowaJ}ou OQ :310N 'llNn 6u!a!�Iano}!un }uanald o} papaaoxa aq }ou}snw wnw!xew SIHl 9NI31Aa3S 80 9NI11VISNI 3110d39 113MOd 1V:)IH13313 133NN03SI0 a41 'uoipbi algeilejun }uanaad o} pauie}uiew aq }snw Gins ')DOHS 311113313 013n0 HIM NO ANnfNI IVNOSH3d 1N3A3Md O,L -said Alddns se6 wnw!uiw a41 •bui}eaado saoue!Idde paiij se6 plogasno4 aa4}o Ile 4}!M elgel!ene pue}ue}suoo aq }snw 9NINMVMTP ainssaad AIddns a41 -alge} buiMollol a4} ui pa!lioads sa6uea a4} u1gl!M pou!e}u!ew aq }snw saanssaad Alddns se6 }alul S9n1d 310H 9NIAOW3H N3HM NounV33Hd V SV S3AO19 3sn 'dHVHS 39 AVW S310H 1tl13W 133HS 30 S3903 '9NIlVl'13d0 S33NVI1ddV 03MI3 SV9 OlOH35nOH H3H1011V H1IM 31V1d 9NIlVH 9NINZI`dM� 11Nn 3H1 NO C13IJI33dS SV 39 ism 3mnSS3Hd AlddnS SV9131NI 3H1'39VWV01N3WdInb3 SO NOIlVH3dO 319VI13HNn 1N3A3ad Ol NOIIVO01311 X08 NOIlONnr N011nvo •aoueua}u!ew au!}noa ao 'lenowaa as}I!} `uoi}eaado ,apn}!}le 46!4 ao/pue slon}a}euia}le.1o} paainbai s}!N uoisJOA JannOlq ao}elnojio 4}!M aaapa}u!o}}ou}snw 6ui}noa aa!M:310N -uoo /due sapnloui si41 -paildde se6}o ads(} a4} uo a}eaado •Molaq umogs sda}s a4} o}padd!nba aq}snw aoeuan}a41 -sada(}se6 pue 6ui}ea}ndu! Mollol 'xoq uoi}ounf a4} a}eoolai of -suoi}oauuoo leou}oala se6 aoeuan} panoidde a4} sapnlou! a}eld 6ui}ea aoeuan} a41 6uiNew o}.loud }uaw:pedwoo (aannolq jo) aauanq a4}}o ap!s a94}o eqj o} pa}eoolai aq }snw xoq uoi}ounf a4} 'aoeuan} a4} JN/d/d (7NV A7ddnS SVf) jo ap!s a}!soddo a4} 46no.14} suoi}oewoo leou}oola ajew of •(smollumop jol}uaw}aedwoo jamolq)}uaw}aedwoo jauinq a4} -4o}!Ms s14}}ea}ap}ou oa Bulolmas JOI ap!sui pa}eool xoq uoi}ounf a4}ql!M uoi}oauuoo leou}oola ap!s pouado s!.1oop.IaMolq a4}ua4M 06e110A}!un s}dn.ua}ul 4o!4M }46u e.Iol painbi}uoo padd14s si aoeuan}a41 hued apis}}al io qo}!Ms�ooua}ui coop aaMolq a 4}!M paddinba si ooeuinj si41 jgBp a4}aa4}!a g6noa4}apew aq ueO suo!}oauuoo a6e}Ion auiJ •ssal jo sw4o 0 1, aanseaw pino4s aoue}s!sa�{ -Z suoi}oauuoo plai}bui�ew ua4M panaasgo aq}snw a(}uelod au!1 -siauinq a4}jo auo pue uoi}oauuoo -coop aamolq s,}!un a4} uo pa}eool weibe!p (a}!4M) lej}nau a4} uaaM}aq aoue}s!saj ainseaW •I• 6u!a!M a4}ul UmOgs se sailM punoa6 pue `lea}nau '}o4}oauuoC) •Noago bulmollo}a4} -uo!}eool aoeuan}a4}}e pap!Aoid aq}snw}oauuoos!p leou}oala wJoped pue jaMod leou}oala a4}}jo uan}'6uipunoa6}!un aadoad uy -a}eld 6ui}ej }!un a4} uo paipoads uo!}oa}oid }uaijnoaano w I!1uoo of punoa6 leou}Oala ue se 6u!d!d se6 asn }ou oa wnwixew a4}4}!M eouepa000e ui pazis eq}snw aaNeajq}!nollo :31ON •laued leou}oela a4}o}�oeq AeM a4} Ile xoq uo!}ounf ao asn}a41 •aa�eaaq }!nojio ao asn} pue 'ajiM pazis Apadoid aoeuan} a4} ap!su! pa}eool MaJos punoa6 eoewnj a4} woij 6u!uie}uoo }!nojio leou}oole gouejq pasn} a}eaedas a asn uni pinogs ajiM punoa6 a4} `6uipuno.a6}!un aadoad ainsuo of 'VZZ3`dS3 apo0 0lJ10a13 '300:)3I1113313 1VNOIIVN ue!peuBO a41.JO/pue OZ dd=IN ISNV'apo3 3140a13 leuOl}eN 3H1 30 N011103 1S31V1 3H1 H11M'33N3S9V H13H1 a41}o uoi}!pa}sa}el a4} 4}!M 'aouasge ai94} ui 'jo sapoo leool NI SO S3O03 1V301 H11M 33Ntl0a033V NI 030NnON9 4}IM aouepa000e u! papunoa6 Alleou}oola aq}snw aoeuan}a41 sapoo algeo!ldde Ile 4}!M Aldwoo}snw pue 'l, sse10 03N aq AllV:)IHn3l3 39 ism 33VNNn3 3Hl H1V30 snw aoeuan a O /(ddns aaMo a e d bu! ea Iun a u0 a! I NO)DOHS 1V3 1 1113 31 3'AHnfNI 30)1SIN 3H1 OIOAV Ol } 4} } I d } l } } O p �• -Dads}e4}o}puodsajaoo ase4d pue`�(ouanba.I}`a6e}lon I(Iddns i 39d110A H91H a4}}e4}aansua'suoi}oeuuoo leou}oale 4}!M bu!paaooid aaoleg ONINU Ma SNOI103NN0O 3N11 110n 9 L L Permit#: 4269 Permit Date: 11/24/21 Permit Type: RESIDENTIAL MECHANICAL Project Name: Payette Applicant Name: CM Heating Applicant Address: 1415 Broadway Applicant, City, State, Zip: Everett,WA 98201 Contact: Hannah Hageage Phone: 4252590550 Email: hhageage@cmheating.com Scope of Work: Gas furnace install Valuation: 0.00 Square Feet: 0 Number of Stories: 0 Construction Type: Occupancy Group: ID Code: Permit Issued: Permit Expires: 05/23/2022 Form Permit Type: Status: COMPLETE Assigned To: Ameresia Lawlis Property Parcel# Address Legal Description Owner Name Owner Phone Zoning 00874400005700 8327 GALLERY LN NE M OWN PATRICIA 110 DUPLEX Contractors Contractor Primary Contact Phone Address Contractor Type License License# CM HEATING INC 425-259-0550 1500 INDUSTRY CONSTRUCTION Plumbing CMHEAHL750LP ST STE 200 CONTRACTOR Contractor CM HEATING INC 425-259-0550 1500 INDUSTRY CONSTRUCTION Construction CMHEAHL751 W ST STE 200 CONTRACTOR Contractor CM HEATING INC 425-259-0550 1500 INDUSTRY CONSTRUCTION UBI 605890285 ST STE 200 CONTRACTOR Inspections Date Inspection Type Description Scheduled Date Completed Date Inspector Status 01/19/2022 R00.FURNACE 01/20/2022 01/20/2022 BUILDING Approved FINAL Fees Fee Description Notes Amount Processing/Technology $25.00 Inspection $75.00 Forced Air Heat fee per Btu $15.00 Mechanical Base Permit Fee $25.00 Credit Card Service $4.20 Total $144.20 Attached Letters Date Letter Description 12/08/2021 Building Permit Payments Date Paid By Description Payment Type Accepted By Amount 12/07/2021 JOHN GIACOMI 90146425 $140.00 12/07/2021 Ameresia Lawlis $4.20 Outstanding Balance $0.00 Uploaded Files Date File Name 12/08/2021 10264525-PAYETTE MECH PERMIT.pdf 11/24/2021 10189829-4269 Specs.pdf 11/24/2021 10189830-4269 Application.pdf